盛港牌玻鎂平板（俗稱氧化鎂板）是以氧化鎂（MgO）、氯化鎂（MgCl2）和水（H2O）三元體系，經配製和加改性劑而製成的，性能穩定的鎂質膠凝材料、以中碱性玻纖網為增強材料，以輕質材料為填充物復合而成的新型不燃型裝飾材料。它具有質輕高強、收縮性小、易施工等特點，尤其是特有的新型防水、防火、耐腐、可塑性更優于充斥市場的木質多層夾板、紙面石膏板等裝飾材料。
Shenggang Magnesium Plain Board(usually called magnesium oxide board) is combined system of MgO,MgCl2 and H2O alkali agent.The stable magnesium colloid is reinforced by middle alkali glass fiber net and stuffed by light material then becomes new frameless decorative material.It has the features of light quality,strong intensity,little contraction,easy constructing.Especially the unique waterproof,fireproof,corrosion proof and plasticity are better than normally used wooden multisplint,paper surface plaster board etc.
盛港牌玻鎂平板的六大特性
1、 耐火阻燃
經國家權威機構檢測該材料為A級不燃性材料，用其構成的牆體及鋼結構保護耐火極限遠遠高于國家標準。
Fireproof
The material is A class frameless one tested state authority institute.The water absorb and max fire durability meet the demand for light inner partition completely.
2、 耐水防潮
已驗証，該材料在水中浸泡1個月后，仍保持原樣，不發生變形、發脹等現象，其干濕變形率為0.26%，其材料吸水率為15%左右，特別是抗折強度干態為15MPA，吸濕狀態下為22MPA，即吸濕狀態下的強度要更高。
Waterproof and moistureproof
Through experiment and test,after this material has been immersed in the water for one month,it keeps its original shape,without deformation or expansion,its dry-wet deforming ratio is 0.26%,its water-absorbing capacity is 15%,especially the creasing resistance is 15Mpa under the dry condition and 22Mpa under the moisture absorbing condition,i.e. the strenght under the moisture absorbing condition is higher.
3、 保溫隔熱
該材料熱阻為1.14m2.k/w，配合外保溫材料使用可作為一般的外牆使用。
Heat preservation and protection
The thermal resistance is 1.14m2k./w,matched with the exterior heat insulating material,it can be usd as the external walls in general.
4、 隔聲
95MM隔聲牆可達四層12MM石膏板構成的123MM牆體的隔聲標準，相當于150MM普通實心磚牆的隔聲效果。
Sound absorb and insulation
95mm soundproof wall can have a soundproof standard which a 123mm wall made of four layers iof 12mm gypsum plank,which is equal to the soundproof of effect of a 150mm common solid brik wall.
5、輕質高強
10MM的板材重量有10.07Kg/m2，用輕鋼龍骨做牆體后為31.5 Kg/m2，約為普通實心粘土磚牆的1/10，且抗衝擊強度是普通石膏板牆體的2－3倍，安裝方便能有效的縮短工期。
Light quality and high intensity
10mm thick board weights 10.7Kg/m2,use the wall made of light steel keel is 31.5Kg/m2 at about 1/10 of common wall made of solid clay brick while the antiimpact intensity is 2-3 times of normal plaster wall.It can be easoly installed and the constructing time is shortened.
6、 綠色環保
該材料為無機物、植物纖維等天然材料構成，放射性符合國家標準，環保性符合國家要求，是國家政策鼓勵類新產品。
Green environment protection
The material is made of natural materials such as minneral and plant fober ,the environment protection meets our country’s demand.It is new product that our country is encouraging.
盛港牌玻鎂平板施工說明及應用
板材接縫處理
（A） 單層罩面板在龍骨兩側的板縫，以及雙層罩面板在龍骨骨架同一側的內、外層板的板縫，均應錯開排布，即接縫不能落在同一龍骨上。
（B） 板材對接時宜留設3－5MM板縫。
（C） 將板縫清理乾淨，填嵌縫材料（根據玻鎂平板的特點，宜使用彈性嵌縫材料）
（D） 嵌縫材料填科壓實后，將玻纖網帶粘覆在板縫上再抹一層膩子，粘上牛皮紙帶后刮平
The seaming treatment
(A) the seaming of single cover board,or the seaming of two-layer cover board at one side of
inner and outer layer should be arranged stagger,i.e.,not on the same keel.
(B) Please leave the seaming of 3-5mm when the boards dock.
(C) Clean the seaming of the board,then fill the filling material(according to the features of
the board,please use elastic material)
(D) After the filling material has been filled and solid,cover glass net on the seaming and
then paste putty, paste kraft paper and make smooth.
板材表面處理
（A） 對板面進行除塵、除膩、乾燥處理
（B） 選用合適的膠結劑直接貼牆紙、刷油漆、噴塑等簡裝裝飾
（C） 選用合適的膠結劑在板面粘結鋁塑板
（D） 瓷磚貼法：（1）可在表面直接選擇適當瓷磚用膠粘貼
（2）可在板材表面水泥沙漿1：3比例打底，配0.5白灰，挂鋼網拉毛處理，再用水泥沙漿1：1比例粘貼。
Surface treatment of the board
(A) remove dust and putty then make dry treatment
(B) select proper grouting agent to paste wallpaper, paint dope, spray plastic etc
(C) select proper grouting agent to adhere aluminum plastic board
(D) ways of sticking the tiles:
(1) Directly choose the proper tiles to be sticked onto the surface with the glue
(2) Lay a base on the surface of the board with the cement and grout at a ratio of 1:3 plus
0.5 lime,hang a steel mesh to have a roghcasting treatment,then stick with the cement and grout at a ratio of 1:1
管道外包
在現代建筑中，管道外包也很重要，用盛港牌玻鎂板做管道外包敷用，既可防火、防潮、又可起裝飾作用。
Outer package of pipe lines
In modern construction,the packageing of the pipes is also very importment.Packing the pipes withte Shenggang Glass-magnesium can both resist to the fire and moisture and work as the decoration.
|
|
|
|
|
